Advertisement

Novel Activated Microbubbles-based Strategy to Coat Nanoparticles on Root Canal Dentin: Fluid Dynamical Characterization

Published:April 02, 2019DOI:https://doi.org/10.1016/j.joen.2019.02.011

      Highlights

      • Study evaluated fluid dynamics and nanoparticles coating with microbubbles (MB).
      • Ultrasonic activated MB produced inertial dominated stress and dentin mixed coat.
      • Manually activated MB promoted viscosity dominated stress and uniform coat.

      Abstract

      Introduction

      Activated microbubbles (MBs) have the potential to deliver nanoparticles in complex microspaces such as root canals. The objective of the study is to determine the fluid dynamical parameters associated with ultrasonic, sonic, and manual activation of MBs in simulated root canals and to assess the effectiveness of surface coating formed by delivering chitosan nanoparticles using activated MBs within root canals in extracted teeth.

      Methods

      In stage 1, polydimethylsiloxane models were fabricated to determine the physical effects of MBs agitated manually (MM), sonically (MS), and ultrasonically (MU). Spherical tracer particles were used to visualize and record the fluid motion using an inverted microscope linked to a high-speed camera. The velocity, wall stress, and penetration depth were analyzed at regions of interest. In stage 2, 35 extracted human incisors were divided into 7 groups to evaluate the effectiveness of chitosan nanoparticle delivery using activated MBs (MM, MS, and MU groups). Field emission scanning electron microscopy and energy-dispersive X-rays were used to characterize the nanoparticle coating on root canal dentin and the degree of dentinal tubule occlusion.

      Results

      In stage 1, velocity, wall stress, and penetration depth increased significantly in the MB groups compared with the control (P < .01). In stage 2, 70% of the dentin surface was coated, and 65% of the dentinal tubule was occluded with nanoparticle-based coating in the MM, MU, and water ultrasonic groups. Element analysis displayed the presence of dentin smear on the root canal surface for the MU and water ultrasonic groups.

      Conclusions

      Activated MBs enhanced fluid dynamical parameters when compared with water in simulated root canal models. Manual activation of MBs resulted in uniform and significant nanoparticle-based surface coating and tubule blockage in root canal dentin without dentin smear formation.

      Key Words

      To read this article in full you will need to make a payment

      References

        • Peters O.A.
        Accessing root canal systems: requirements and techniques.
        Pract Proced Aesthet Dent. 2006; 18: 277-279
        • Kishen A.
        Mechanisms and risk factors for fracture predilection in endodontically treated teeth.
        Endod Topics. 2006; 13: 57-83
        • Kishen A.
        Advanced therapeutic options for endodontic biofilms.
        Endod Topics. 2012; 22: 99-123
        • Tan W.
        • Krishnaraj R.
        • Desai T.A.
        Evaluation of nanostructured composite collagen–chitosan matrices for tissue engineering.
        Tissue Eng. 2001; 7: 203-210
        • Kishen A.
        • Shi Z.
        • Shrestha A.
        • Neoh K.G.
        An investigation on the antibacterial and antibiofilm efficacy of cationic nanoparticulates for root canal disinfection.
        J Endod. 2008; 34: 1515-1520
        • Shrestha A.
        • Cordova M.
        • Kishen A.
        Photoactivated polycationic bioactive chitosan nanoparticles inactivate bacterial endotoxins.
        J Endod. 2015; 41: 686-691
        • Shrestha A.
        • Friedman S.
        • Kishen A.
        Photodynamically crosslinked and chitosan-incorporated dentin collagen.
        J Dent Res. 2011; 90: 1346-1351
        • Shrestha A.
        • Hamblin M.R.
        • Kishen A.
        Photoactivated rose bengal functionalized chitosan nanoparticles produce antibacterial/biofilm activity and stabilize dentin-collagen.
        Nanomedicine. 2014; 10: 491-501
        • Kishen A.
        • Shrestha S.
        • Shrestha A.
        • et al.
        Characterizing the collagen stabilizing effect of crosslinked chitosan nanoparticles against collagenase degradation.
        Dent Mater. 2016; 32: 968-977
        • Shrestha A.
        • Fong S.W.
        • Khoo B.C.
        • Kishen A.
        Delivery of antibacterial nanoparticles into dentinal tubules using high-intensity focused ultrasound.
        J Endod. 2009; 35: 1028-1033
        • Sirsi S.
        • Borden M.
        Microbubble compositions, properties and biomedical applications.
        Bubble Sci Eng Technol. 2009; 1: 3-17
        • George S.
        • Kishen A.
        Augmenting the antibiofilm efficacy of advanced noninvasive light activated disinfection with emulsified oxidizer and oxygen carrier.
        J Endod. 2008; 34: 1119-1123
        • Grapentin C.
        • Barnert S.
        • Schubert R.
        Monitoring the stability of perfluorocarbon nanoemulsions by Cryo-TEM image analysis and dynamic light scattering.
        PLoS One. 2015; 10: e0130674
        • Halford A.
        • Ohl C.D.
        • Azarpazhooh A.
        • et al.
        Synergistic effect of microbubble emulsion and sonic or ultrasonic agitation on endodontic biofilm in vitro.
        J Endod. 2012; 38: 1530-1534
        • Mullin L.B.
        • Phillips L.C.
        • Dayton P.A.
        Nanoparticle delivery enhancement with acoustically activated microbubbles.
        IEEE Trans Ultrason Ferroelectr Freq Control. 2013; 60: 65-77
        • Layton G.
        • Wu W.I.
        • Selvaganapathy P.R.
        • et al.
        Fluid dynamics and biofilm removal generated by syringe-delivered and 2 ultrasonic-assisted irrigation methods: a novel experimental approach.
        J Endod. 2015; 41: 884-889
        • Martinez-Duarte R.
        • Madou M.J.
        SU-8 photolithography and its impact on microfluidics.
        in: Mitra S.K. Chakraborty S. Microfluidics and Nanofluidics Handbook: Fabrication, Implementation, and Applications. CRC Press Taylor & Francis Group, Boca Raton, FL2012: 231-268
        • Xia Y.
        • Whitesides G.M.
        Soft lithography.
        Annu Rev Mater Sci. 1998; 28: 153-184
        • Machtou P.
        Manual dynamic activation (MDA) technique.
        in: Basrani B. Endodontic Irrigation. Springer International Publishing, New York2015: 149-155
        • Leal L.G.
        Advanced Transport Phenomena: Fluid Mechanics and Convective Transport Processes.
        Cambridge University Press, Cambridge, UK2007
        • Shi Z.
        • Neoh K.G.
        • Kang E.T.
        • Wang W.
        Antibacterial and mechanical properties of bone cement impregnated with chitosan nanoparticles.
        Biomaterials. 2006; 27: 2440-2449
        • Koch J.
        • Borg J.
        • Mattson A.
        • et al.
        An in vitro comparative study of intracanal fluid motion and wall shear stress induced by ultrasonic and polymer rotary finishing files in a simulated root canal model.
        ISRN Dent. 2012; 2012: 764041
        • de Groot S.D.
        • Verhaagen B.
        • Versluis M.
        • et al.
        Laser-activated irrigation within root canals: cleaning efficacy and flow visualization.
        Int Endod J. 2009; 42: 1077-1083
        • Li Y.
        • Pan C.
        • Li Y.
        • et al.
        An exploration of the reflow technique for the fabrication of an in-vitro microvascular system to study occlusive clots.
        Biomed Microdevices. 2017; 19: 82
        • Asundi A.
        • Kishen A.
        Advanced digital photoelastic investigations on the tooth-bone interface.
        J Biomed Opt. 2001; 6: 224-230
        • Ossareh A.
        • Rosentritt M.
        • Kishen A.
        Biomechanics studies on the effect of iatrogenic dentin removal on vertical root fracture.
        J Conserv Dent. 2018; 21: 290-296
        • Lo Giudice G.
        • Cutroneo G.
        • Centofanti A.
        • et al.
        Dentin morphology of root canal surface: a quantitative evaluation based on a scanning electronic microscopy study.
        Biomed Res Int. 2015; 2015: 164065
        • Chen J.E.
        • Nurbakhsh B.
        • Layton G.
        • et al.
        Irrigation dynamics associated with positive pressure, apical negative pressure and passive ultrasonic irrigations: a computational fluid dynamics analysis.
        Aust Endod J. 2014; 40: 54-60
        • Jiang L.M.
        • Verhaagen B.
        • Versluis M.
        • van der Sluis L.W.
        Evaluation of a sonic device designed to activate irrigant in the root canal.
        J Endod. 2010; 36: 143-146
        • Gu L.S.
        • Kim J.R.
        • Ling J.
        • et al.
        Review of contemporary irrigant agitation techniques and devices.
        J Endod. 2009; 35: 791-804
        • van der Sluis L.W.
        • Versluis M.
        • Wu M.K.
        • Wesselink P.R.
        Passive ultrasonic irrigation of the root canal: a review of the literature.
        Int Endod J. 2007; 40: 415-426
        • Deen W.M.
        Fundamentals of fluid mechanics - dimensionless group and flow regimes.
        in: Deen W.M. Analysis of Transport Phenomena. 2nd ed., Chapter 6.9. Oxford University Press, Inc, New York1947: 261-265
        • Gulabivala K.
        • Ng Y.L.
        • Gilbertson M.
        • Eames I.
        The fluid mechanics of root canal irrigation.
        Physiol Meas. 2010; 31: R49-R84
        • Krainov V.P.
        Qualitative Methods in Physical Kinetics and Hydrodynamics.
        American Institute of Physics, New York, NY1992
        • Eckstein E.C.
        • Bailey D.G.
        • Shapiro A.H.
        Self diffusion of particles in shear flow of a suspension.
        Fluid Mech. 1976; 79: 191-208
        • Taravel M.N.
        • Domard A.
        Relation between the physicochemical characteristics of collagen and its interactions with chitosan: I.
        Biomaterials. 1993; 14: 930-938
        • Boutsioukis C.
        • Tzimpoulas N.
        Uncontrolled removal of dentin during in vitro ultrasonic irrigant activation.
        J Endod. 2016; 42: 289-293